PENGGANTIAN ALAT PENDUKUNG REAKTOR ANAEROBIK DUA TAHAP GUNA MENINGKATKAN KUALITAS HASIL BIOGAS

Mukhtar Ghozali, Herawati Budiastuti, Alviera Wilma Fitrianie, Elis Sri Wahyuni

Abstract


BOD/COD ratio of leachate is 0.6 so it fulfils requirement for anaerobic treatment. Leachate is potentially to be treated, however leachate is commonly treated by aeration before it is discharged. To avoid environmental pollution and to optimize treatment, leachate can be treated anaerobically to produce biogas. Two-stage anaerobic reactors are considered to be more effective and efficient in degrading organic substances in leachate. This study aims to evaluate the reactors built to increase degradation efficiency and composition of CH4 contained in biogas. To improve reactor’s performance, the feed tank replacement, leackage check, and gas holder replacement were conducted. Leachate was obtained from Sarimukti Padalarang, West Bandung and starter, cow rumen, was obtained from a slaughter house in Ciroyom, Bandung. The value of pH in the 1st reactor (R1) was in the range of 5-6.5 and in the 2nd reactor (R2) was 7-8. Acidic pH range allows the occurrence of hydrolysis and acetogenesys, meanwhile the normal pH range allows the occurrence of methanogenesys. Analysis parameters were COD, BOD, pH, and composition of CH4  in biogas. CH4 produced within 45 days,  COD degradation efficiency, and maximum CH4 composition were 2 liters, 86.9%, and 24%, respectively. CH4 was started to be produced after day 18.

Full Text:

PDF

References


Alimba, C.G., Bakare, A.A., and Arinola, O.G. 2009. “Effects of Municipal Solid Waste Leachate on Leucocyte and Differential Counts in Rats”. Global Journal of Environmental Research, Vol. 3, No. 3, pp. 135-140.

Wicaksono, H.K. dan Hadiansyah R. 2016. Pemanfaatan Sampah Pasar menjadi Biogas dengan Metode Anaerobik Dua Tahap, Tugas Akhir, Jurusan Teknik Kimia, Politeknik Negeri Bandung, Bandung.

Hermanus, M.B., Polii, B., dan Mandey, L.C., 2015. “Pengaruh Perlakuan Aerob dan Anaerob Terhadap Variabel BOD, COD, pH, dan Bakteri Dominan Limbah Industri Desiccated Coconut PT. Global Coconut Radey, Minahasa Selatan”. J. Ilmu dan Teknologi Pangan, Vol. 3, No.2, pp 48-58.

Budiastuti, H., Ghozali, M., Wicaksono, H.K., and Hadiansyah R., 2018. “Two Stage Anaerobic Reactor Design and Treatment To Produce Biogas From Mixed Liquor of Vegetable Waste”. J. Physics: Conference Series, Vol 953, pp. 1-8.

Mshandete, A.M., dkk., 2008. “Two Stage Anaerobic Digestion Pre-treated Sisal Leaf Decortication Residues : Hydrolases Activities and Biogas Production Profile”. African Journal of Biochemistry Research, Vol. 2, No. 11, pp. 211-218.

Tillman, D.A. 1991. Ilmu Makanan Ternak Dasar. Yogyakarta : Gadjah Mada University Press.

Febriani, 2011. Fisilogi Mikroba : Bakteri Rumen. Fakultas Matematika dan Ilmu Pengetahuan Alam, Universitas Riau, Riau.

Mujdalipah, S. dkk., 2014. “Pengaruh Waktu Fermentasi Terhadap Produksi Biogas menggunakan Digester Dua Tahap Pada Berbagai Konsentrasi Palm Oil-Mill Effluent dan Lumpur Aktif”. AGRITECH, Vol. 34, No.1, pp 56-64.

Caturwati, N.K. dkk 2017. “Pengaturan Waktu Produksi Biogas dari Limbah Padat Organik dengan Air Lindi sebagai Starter dalam Anaerobic Digester untuk Mendapatkan Produksi yang Kontinu” Jurnal Jurusan Teknik Mesin, Untirta, Vol. 3, No. 1, pp. 63-68.

Hariyanto, S., Citrasari, N., dan Soediarti, T. 2014. Karakterisasi Lindi Tempat Pembuangan Akhir (TPA) Sampah Sebagai Data Rancangan Teknologi Pengolahan Limbah Cair. Lembaga Penelitian Universitas Airlangga, Surabaya.




DOI: https://doi.org/10.31884/jtt.v4i2.150

Refbacks

  • There are currently no refbacks.


Copyright (c) 2018 JTT (Jurnal Teknologi Terapan)

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.

View Stats

 

 Creative Common Attribution-ShareAlike 4.0 International (CC BY-SA 4.0)